PLUG POWER INC is a large fleet motor carrier based in SLINGERLANDS, New York (USDOT #956300). As of 2026-10-15T01:31:11.325Z, it holds a Not Rated FMCSA safety rating and a FileFlo Carrier Intelligence Score of 88/100 (Low Risk), based on 50 recent inspection(s) and 26 recorded violation(s) in public FMCSA data.
Free FMCSA Audit · 60 seconds · No signup
Run a CFR-cited gap audit on PLUG POWER INC
Pulls the same Socrata data shown above. Grades against the rule pack FileFlo runs internally. Every gap names its 49 CFR section.
Take the book. Free.
238 pages on the paperwork side of trucking. Every checklist in it, yours.
The complete digital edition · Every checklist and template · Unsubscribe anytime
Free FMCSA record alerts
Is this your company? Get free alerts when this record changes.
FileFlo emails you the morning the public FMCSA record for PLUG POWER INC shows a new roadside inspection, an insurance cancellation or suspension notice, an authority change, the MCS-150 update coming due, or a safety rating change. Free, and FileFlo is not the DOT.
Turn on free alerts88/100 Low Risk
| Category | Score | Max |
|---|---|---|
| Safety Rating | 22 | 30 |
| Inspection Pass Rate | 20 | 20 |
| Out-of-Service Rate (vs FMCSA national avg) | 15 | 15 |
| CSA BASIC percentiles | Not measured | n/a |
CIS subtotal normalizes 3 publicly-available FMCSA components (Safety Rating + Inspection Pass Rate + OOS Rate) to a 0-100 surface. CSA SMS BASIC percentiles are not published in FMCSA's public Socrata datasets and the SMS portal at ai.fmcsa.dot.gov is not crawlable at scale, so we surface a transparent "Not measured" rather than fabricate a score component. Carriers with a Compliance Review on record may have published BASIC data on the SAFER snapshot for that DOT.
PLUG POWER INC is a large fleet operating out of SLINGERLANDS, New York with USDOT number 956300. The company operates 127 power units and has no published FMCSA safety rating (most active carriers are unrated unless they have undergone a compliance review). Based on our analysis of federal safety data, PLUG POWER INC has a FileFlo Carrier Intelligence Score (CIS) of 88/100, classified as Low Risk.
PLUG POWER INC has undergone 50 recorded DOT inspections. The vehicle out-of-service rate is 4.0%, which is below the national average of 20.72%, suggesting solid vehicle maintenance practices.
The public FMCSA record for PLUG POWER INC carries 26 recorded violations, and the most recent inspection on file is dated 20261012. Across 50 recorded inspections, the record carries 0 driver out-of-service violations and 2 vehicle out-of-service violations.
A recorded violation is what an inspector wrote down at the roadside. It is not a penalty, and it is not an amount owed: FMCSA assesses civil penalties only after a compliance review classifies specific cited violations. The step that changes this record is the document behind each line, so the next move is to see which records an investigator would ask for and which of them exist today.
A CIS score of 88 places PLUG POWER INC in the Low Risk category. This carrier demonstrates strong safety practices across inspections, maintenance, and driver compliance. Maintaining this score requires ongoing document tracking, timely medical card renewals, and consistent pre-trip inspections.
Motor carriers operating in New York must comply with both federal FMCSA regulations and state-specific transportation requirements. The SLINGERLANDS, NY corridor is monitored by FMCSA field offices and state highway patrol units conducting roadside inspections. Carriers based in SLINGERLANDS should ensure driver qualification files, vehicle inspection reports, and hours-of-service records are current and audit-ready at all times.
PLUG POWER INC falls under the Eastern Service Center for FMCSA field-office oversight (region code 01). Service-center territory drives which FMCSA Investigator team would conduct a new-entrant audit or compliance review if one is triggered for this carrier.
FileFlo helps New York trucking companies automate compliance document tracking across 600+ document types, including CDL medical cards, annual vehicle inspections, drug & alcohol testing records, and driver training certifications.
PLUG POWER INC is classified by FMCSA as an interstate carrier.
The carrier holds an Authorized For Hire classification, meaning it transports cargo or passengers for compensation under FMCSA operating authority and is subject to MC-number requirements at 49 CFR Part 365.
PLUG POWER INC is flagged in FMCSA Census as a hazardous materials carrier (HM indicator: Y). Hazmat carriers are subject to additional regulations under 49 CFR Subchapter C, including HM-126 reporting, HM-232 security planning, and the Hazmat Cargo Tank Annual Inspection requirement (49 CFR 180.407). Hazmat violations carry their own, higher penalty schedule, separate from the general FMCSA schedule.
Operational range per MCS-150 filing: interstate beyond 100 miles (long-haul, 23 drivers); interstate within 100 miles (short-haul, 2 drivers); intrastate beyond 100 miles (1 drivers); intrastate within 100 miles (1 drivers). The 100-mile boundary matters because drivers operating within a 100-air-mile radius qualify for the short-haul exception under 49 CFR 395.1(e)(1), which removes the requirement to maintain RODS for the day.
Self-reported MCS-150 annual mileage: 2,364,515 miles. MCS-150 mileage feeds the FMCSA SafeStat exposure denominator: drastically understated mileage can artificially inflate CSA BASIC percentile scores by reducing the per-mile exposure baseline. Updates are required every 24 months under 49 CFR 390.19.
Owned equipment per the FMCSA Census filing: 2 straight trucks. Owned-vs-leased equipment matters for compliance documentation, owned trailers require the carrier to retain annual inspection certificates under 49 CFR 396.17, while leased trailers shift that documentation responsibility to the lease agreement.
The carrier reports 27 CDL-holding drivers on file. Each CDL driver must have a current Driver Qualification File (DQF) maintained per 49 CFR 391.51, including a Medical Examiner's Certificate, an annual MVR review, and a record of road-test results.
Intrastate driver count: 2. Intrastate drivers may be subject to state-specific CDL endorsement and hours-of-service variances depending on the state.
Primary cargo type per MCS-150: Fuel Cell Systems. Cargo type drives which BASIC categories the carrier is monitored under (Hazmat Compliance applies only to HM-flagged carriers; Cargo-Related Crash applies broadly).
The FMCSA Motor Carrier Management Information System (MCMIS) crash dataset records 7 crash events involving PLUG POWER INC in the available reporting window. Of these, 0 involved a fatality, 2 involved a reported injury, and 7 resulted in a tow-away. 7 events meet the federal-recordable threshold under 49 CFR 390.5 (fatality, injury treated away from the scene, OR tow-away of any vehicle).
Federal-recordable crashes feed the Crash Indicator BASIC in CSA: carriers above the intervention threshold are 7-10x more likely to be selected for a compliance review than peer carriers below the threshold. Insurance carriers also pull federal-recordable crash counts during quoting; a single recordable crash in a 24-month look-back can drive a 10-20% premium increase for owner-operators and small fleets.
Most recent recorded event: US0060, PADUCAH, KY on 20260714.
Inspections cluster geographically across Kentucky (12), Georgia (5), South Carolina (4). The concentration in Kentucky is consistent with the carrier's primary lanes and tends to correlate with which state DOT inspector teams PLUG POWER INC's drivers encounter most often at roadside checkpoints.
Across the 50 recorded inspections, PLUG POWER INC's 4.0% vehicle out-of-service rate sits well below the FMCSA 2024 national average of 20.72%. The 0.0% driver out-of-service rate sits materially below the 2024 national average of 5.51%. Vehicle OOS-rate variance is the strongest predictor of Vehicle Maintenance BASIC scores in CSA; driver OOS-rate variance is the strongest predictor of Hours-of-Service Compliance + Driver Fitness BASIC scores.
FMCSA's intervention thresholds (the percentile bands that trigger investigator outreach) are roughly 65th percentile for non-passenger non-hazmat carriers (75th for hazmat, 70th for passenger) on each BASIC. Carriers that consistently sit above the national average across multiple BASICs accumulate intervention risk faster than carriers with mixed performance. A single high BASIC alone rarely triggers enforcement; sustained over-threshold performance does.
The self-serve Audit-Ready Setup covers carriers up to 50 power units. A fleet of 127 power units is scoped with a person: tell us how USDOT 956300 is run, how many drivers and files are in scope, and we come back with the scope and the price for that.
Talk to us about PLUG POWER INC
Want the gap list first? Run the free FMCSA audit for PLUG POWER INC: sixty seconds, no signup, every gap cited to the 49 CFR section. See pricing. Read the founder's FMCSA Audit Survival Guide.
Broker or insurance agent? Partner program
Open any inspection for the records an auditor would ask for behind it: free, from USDOT 956300, no signup.
| Date | State | Driver OOS | Vehicle OOS | Next step |
|---|---|---|---|---|
| 2026-10-12 | NC | 0 | 0 | Audit check |
| 2026-09-28 | KY | 0 | 0 | Audit check |
| 2026-09-11 | NV | 0 | 0 | Audit check |
| 2026-08-24 | NC | 0 | 0 | Audit check |
| 2026-08-20 | SC | 0 | 0 | Audit check |
| 2026-08-18 | PA | 0 | 0 | Audit check |
| 2026-08-11 | SC | 0 | 0 | Audit check |
| 2026-08-10 | KY | 0 | 0 | Audit check |
| 2026-08-06 | KY | 0 | 0 | Audit check |
| 2026-08-03 | KY | 0 | 0 | Audit check |
Free · No signup
Run a free FMCSA audit on your fleet
Walks every 49 CFR section a new-entrant audit or compliance review actually checks. Every gap names the CFR section that cites it. No signup, no credit card.
PLUG POWER INC (USDOT #956300) does not currently carry a published FMCSA safety rating. A "Not Rated" status is common for carriers that have never had a compliance review: it is not a negative finding. FileFlo scores the carrier at 88/100 (Low Risk) from the public inspection and out-of-service data that is available.
Per its most recent FMCSA MCS-150 filing, PLUG POWER INC operates 127 power unit(s) and 27 driver(s), classifying it as a large fleet. Fleet counts are self-reported to FMCSA and can lag a carrier's current operation.
PLUG POWER INC is registered with the FMCSA at a physical address in SLINGERLANDS, New York, under USDOT number 956300.
FileFlo shows 50 recent DOT inspection(s) and 26 recorded violation(s) for PLUG POWER INC (USDOT #956300), sourced from FMCSA public records and the Socrata transportation datasets. The inspection table on this page lists dates, states, and out-of-service counts.
PLUG POWER INC scores 88/100 (Low Risk) on FileFlo's Carrier Intelligence Score. The score normalizes three public FMCSA components (safety rating, inspection pass rate, and out-of-service rate versus the national average) into one 0-100 surface. CSA SMS BASIC percentiles are not published in FMCSA's public data and are excluded rather than estimated.
The 49 CFR sections a DOT compliance review actually checks, plain-English:
Compliance terms: CSA score · out-of-service order · hours of service · driver qualification file. See DOT compliance software & document management →
← Browse All Carriers · New York Carriers · 2026 FMCSA Penalty Guide · Free FMCSA Audit
Compare the best FMCSA audit prep software →
Data sourced from FMCSA public records and the Socrata transportation dataset. Last updated: 2026-10-15T01:31:11.325Z. Information may not reflect the carrier's current status. Dispute this record · Claim this profile