EMR XPRESS LLC, DOT #3663007 FMCSA Safety & Compliance Report
Your drivers have been put out of service on every inspection since December 10, 2024: Wisconsin on Dec. 10, 2024, Sept. 10, 15 and 16.
Every one included a driver qualification violation.
Your MCS-150 lists 6 trucks and 4 drivers.
Every violation on this list stays on your FMCSA record for 24 months and counts toward the scores FMCSA uses to choose carriers for an investigation. The investigator asks for the files behind each one.
EMR XPRESS LLC is a small fleet motor carrier based in MILWAUKEE, Wisconsin (USDOT #3663007). As of October 28, 2026, it holds a Not Rated FMCSA safety rating and a FileFlo Carrier Intelligence Score of 39/100 (High Risk), based on 10 recent inspection(s) and 33 recorded violation(s) in public FMCSA data.
What EMR XPRESS LLC's record points to
- What out-of-service inspections trigger: the expedited safety audit (49 CFR 385.308)
Out of service on 4 inspections of 5 in the last 24 months, most recently September 16. - Insurance cancelled or authority revoked: what happens and what stops it
A BMC-91X filing from Artisan & Truckers Casualty Company was cancelled effective January 15, 2025. - Have FileFlo run your compliance department
Driver files, renewals, Clearinghouse queries, MVRs, drug and alcohol testing and the audit packet, run for you.
Free FMCSA Audit · 60 seconds · No signup
Run a CFR-cited gap audit on EMR XPRESS LLC
Pulls the same Socrata data shown above. Grades against the rule pack FileFlo runs internally. Every gap names its 49 CFR section.
Take the book. Free.
238 pages on the paperwork side of trucking. Every checklist in it, yours.
The complete digital edition · Every checklist and template · Unsubscribe anytime
Free FMCSA record alerts
Is this your company? Get free alerts when this record changes.
FileFlo emails you the morning the public FMCSA record for EMR XPRESS LLC shows a new roadside inspection, an insurance cancellation or suspension notice, an authority change, the MCS-150 update coming due, or a safety rating change. Free, and FileFlo is not the DOT.
Turn on free alertsCarrier Intelligence Score
39/100 High Risk
| Category | Score | Max |
|---|---|---|
| Safety Rating | 22 | 30 |
| Inspection Pass Rate | 5 | 20 |
| Out-of-Service Rate (vs FMCSA national avg) | 7 | 15 |
| CSA BASIC percentiles | Not measured | n/a |
Three public FMCSA components, scored by FileFlo. CSA BASIC percentiles are not in FMCSA's public data, so they are shown as not measured.
EMR XPRESS LLC's public FMCSA record, line by line
Roadside inspections in the last 24 months
- Sept. 16, 2026, Wisconsin. Out of service: 1 driver violation, 3 violations in all. Written up for a disqualified driver (49 CFR 391.15), a state or local traffic violation (49 CFR 392.2), and lights not working (49 CFR 393.9).
- Sept. 15, 2026, Wisconsin. Out of service: 2 driver violations, 4 violations in all. Written up for no valid medical card (49 CFR 391.41), no logbook kept the required way (49 CFR 395.8), speeding (49 CFR 392.2), and a disqualified driver (49 CFR 391.15).
- Sept. 10, 2026, Wisconsin. Out of service: 1 driver violation, 7 violations in all. Written up for a disqualified driver (49 CFR 391.15), speeding (49 CFR 392.2), company name or USDOT number not shown on the truck (49 CFR 390.21), and no logbook kept the required way (49 CFR 395.8).
- Dec. 10, 2024, Wisconsin. Out of service: 1 driver violation, 2 violations in all. Written up for a driver qualification violation (49 CFR 391.11) and a driving rule violation (49 CFR 392.16).
- Nov. 4, 2024, Wisconsin. 1 violation, none out of service. Written up for a state or local traffic violation (49 CFR 392.2).
Operating authority and insurance
FMCSA's licensing record shows MC1267185, motor property common carrier authority, reinstated on February 28, 2022.
2 BMC-91X liability filings were cancelled on FMCSA's insurance record in the last 24 months, most recently Artisan & Truckers Casualty Company's, effective January 15, 2025.
When the policy behind a BMC-91X is cancelled, the insurer must give FMCSA 30 days' notice (49 CFR 387.313(d)), and FMCSA starts revoking the operating authority unless a replacement filing is on record.
EMR XPRESS LLC: MILWAUKEE, Wisconsin Trucking Company
EMR XPRESS LLC is a small fleet operating out of MILWAUKEE, Wisconsin with USDOT number 3663007. The company operates 6 power units and has no published FMCSA safety rating (most active carriers are unrated unless they have undergone a compliance review). Based on our analysis of federal safety data, EMR XPRESS LLC has a FileFlo Carrier Intelligence Score (CIS) of 39/100, classified as High Risk.
FMCSA Safety Record & Inspection History
EMR XPRESS LLC has undergone 10 recorded DOT inspections. The vehicle out-of-service rate is 20.0%, which is below the national average of 20.72%, suggesting solid vehicle maintenance practices. The driver out-of-service rate is 50%, above the national average of 5.51%. Common causes include hours-of-service violations, expired medical certificates, and CDL issues.
Recorded Violations and Out-of-Service Status
The public FMCSA record for EMR XPRESS LLC carries 33 recorded violations, and the most recent inspection on file is dated September 16, 2026. Across 10 recorded inspections, the record carries 6 driver out-of-service violations and 2 vehicle out-of-service violations.
A recorded violation is what an inspector wrote down at the roadside. It is not a penalty, and it is not an amount owed: FMCSA assesses civil penalties only after a compliance review classifies specific cited violations. The step that changes this record is the document behind each line, so the next move is to see which records an investigator would ask for and which of them exist today.
What a 39/100 Carrier Intelligence Score Means
The Carrier Intelligence Score is FileFlo's own summary of three public FMCSA components for EMR XPRESS LLC: the safety rating, the inspection pass rate and the out-of-service rate against the national average. It is not an FMCSA score, and FMCSA does not use it to choose carriers for an investigation. 39 out of 100 falls in FileFlo's High Risk band.
Authority Type, Hazmat Status, and Operating Profile
EMR XPRESS LLC is classified by FMCSA as an interstate carrier.
The carrier holds an Authorized For Hire classification, meaning it transports cargo or passengers for compensation under FMCSA operating authority and is subject to MC-number requirements at 49 CFR Part 365.
EMR XPRESS LLC is not flagged in FMCSA Census as a hazmat carrier (HM indicator: N), so the carrier is not subject to the additional 49 CFR Subchapter C hazmat regulations.
Operational range per MCS-150 filing: interstate beyond 100 miles (long-haul, 2 drivers); interstate within 100 miles (short-haul, 2 drivers). The 100-mile boundary matters because drivers operating within a 100-air-mile radius qualify for the short-haul exception under 49 CFR 395.1(e)(1), which removes the requirement to maintain RODS for the day.
Self-reported MCS-150 annual mileage: 102,000 miles. MCS-150 mileage feeds the FMCSA SafeStat exposure denominator: drastically understated mileage can artificially inflate CSA BASIC percentile scores by reducing the per-mile exposure baseline. Updates are required every 24 months under 49 CFR 390.19.
Fleet Composition and Driver Profile
Owned equipment per the FMCSA Census filing: 2 straight trucks, 1 tractor, 1 trailer. Owned-vs-leased equipment matters for compliance documentation, owned trailers require the carrier to retain annual inspection certificates under 49 CFR 396.17, while leased trailers shift that documentation responsibility to the lease agreement.
The carrier reports 1 CDL-holding driver on file. Each CDL driver must have a current Driver Qualification File (DQF) maintained per 49 CFR 391.51, including a Medical Examiner's Certificate, an annual MVR review, and a record of road-test results.
How EMR XPRESS LLC Compares to the National Average
Across the 10 recorded inspections, EMR XPRESS LLC's 20.0% vehicle out-of-service rate sits slightly below the FMCSA 2024 national average of 20.72%. The 50.0% driver out-of-service rate sits substantially above the 2024 national average of 5.51%.
Have EMR XPRESS LLC's compliance file built for you
Your last out-of-service was 42 days ago.
Your driver files, kept current by FileFlo's software.
Every driver's file built and kept current, every expiration and renewal date in front of you before it lapses, and the audit packet ready on demand. For 5 trucks or 50.
The Audit-Ready Setup is $499. Send your paperwork and USDOT 3663007; FileFlo files every record against the 49 CFR section that requires it, assembles a driver qualification file per driver, builds the vehicle files, and delivers a gap list with the automatic-failure items first plus your audit packet indexed to the CFR. 30 days, every dollar back: if you are not happy with the Setup within 30 days of purchase, FileFlo refunds the full Setup price. Your first 30 days of FileFlo are included. After your 30 included days, Core continues at $199 a month (Fleet, $399, for 16 to 50 trucks) on the same card unless you cancel. We email you 7 days and 1 day before the first charge, and one click in either email cancels it.
- A full gap report inside 24 hours, with the regulation behind every line
- Driver qualification files, vehicle files, and the audit packet in FMCSA review format
- The Radar on USDOT 3663007: one email the day the public record changes
- The guarantee above, printed word for word on the price card
Start the Audit-Ready Setup for EMR XPRESS LLC →
Or have FileFlo run it for you: the FileFlo Compliance Department, $1,500 a month, Setup included.
FileFlo
FileFloQuestions: sales@getfileflo.com
See the work: a sample audit packet · how FileFlo handles your data
Want the gap list first? Run the free FMCSA audit for EMR XPRESS LLC: sixty seconds, no signup, every gap cited to the 49 CFR section. Or get your free readiness score. See pricing. Read the founder's FMCSA Audit Survival Guide.
Broker or insurance agent? Partner program
Recent DOT Inspections: EMR XPRESS LLC
Open any inspection for the records an auditor would ask for behind it: free, from USDOT 3663007, no signup.
| Date | State | Driver OOS | Vehicle OOS | Next step |
|---|---|---|---|---|
| 2026-09-16 | WI | 1 | 0 | Audit check |
| 2026-09-15 | WI | 2 | 0 | Audit check |
| 2026-09-10 | WI | 1 | 0 | Audit check |
| 2024-12-10 | WI | 1 | 0 | Audit check |
| 2024-11-04 | WI | 0 | 0 | Audit check |
| 2024-10-27 | WI | 0 | 0 | Audit check |
| 2024-10-07 | WI | 1 | 0 | Audit check |
| 2024-09-21 | WI | 0 | 1 | Audit check |
| 2024-06-26 | WI | 0 | 0 | Audit check |
| 2024-01-05 | WI | 0 | 1 | Audit check |
Free · No signup
Run a free FMCSA audit on your fleet
Walks every 49 CFR section a new-entrant audit or compliance review actually checks. Every gap names the CFR section that cites it. No signup, no credit card.
Frequently asked questions about EMR XPRESS LLC
What is EMR XPRESS LLC's FMCSA safety rating?
EMR XPRESS LLC (USDOT #3663007) does not currently carry a published FMCSA safety rating. A "Not Rated" status is common for carriers that have never had a compliance review: it is not a negative finding. FileFlo scores the carrier at 39/100 (High Risk) from the public inspection and out-of-service data that is available.
How large is EMR XPRESS LLC's fleet?
Per its most recent FMCSA MCS-150 filing, EMR XPRESS LLC operates 6 power unit(s) and 4 driver(s), classifying it as a small fleet. Fleet counts are self-reported to FMCSA and can lag a carrier's current operation.
Where is EMR XPRESS LLC based?
EMR XPRESS LLC is registered with the FMCSA at a physical address in MILWAUKEE, Wisconsin, under USDOT number 3663007.
What is EMR XPRESS LLC's DOT inspection and violation history?
FileFlo shows 10 recent DOT inspection(s) and 33 recorded violation(s) for EMR XPRESS LLC (USDOT #3663007), sourced from FMCSA public records and the Socrata transportation datasets. The inspection table on this page lists dates, states, and out-of-service counts.
What is EMR XPRESS LLC's FileFlo Carrier Intelligence Score?
EMR XPRESS LLC scores 39/100 (High Risk) on FileFlo's Carrier Intelligence Score. The score normalizes three public FMCSA components (safety rating, inspection pass rate, and out-of-service rate versus the national average) into one 0-100 surface. CSA SMS BASIC percentiles are not published in FMCSA's public data and are excluded rather than estimated.
Federal rules a carrier like EMR XPRESS LLC is audited against
The 49 CFR sections a DOT compliance review actually checks, plain-English:
- 49 CFR 395.8, Hours of service & ELD records
- 49 CFR 391.51, Driver qualification files (DQF)
- 49 CFR 396.3, Vehicle inspection, repair & maintenance
- 49 CFR 382.301, Pre-employment drug & alcohol testing
Compliance terms: CSA score · out-of-service order · hours of service · driver qualification file. See DOT compliance software & document management →
More Wisconsin carriers on file
- I-TEAM TRUCKING LLC, CEDARBURG (USDOT 3665316)
- JBW TRANSPORTATION INC, KENOSHA (USDOT 3666214)
- SCHMIDT'S LANDSCAPING LLC, SHEBOYGAN FLS (USDOT 3669592)
- BARNARD FARMS LLC, GREEN BAY (USDOT 3670918)
- PETE TRANSPORT LLC, MINERAL POINT (USDOT 3671529)
- SUNDANCE LAWNCARE INC, STURTEVANT (USDOT 3671647)
← Browse All Carriers · Wisconsin Carriers · 2026 FMCSA Penalty Guide · Free FMCSA Audit
Compare the best FMCSA audit prep software →
Data sourced from FMCSA public records and the Socrata transportation dataset. Last updated: October 28, 2026. Information may not reflect the carrier's current status. Dispute this record · Claim this profile