WALTHAM, Massachusetts · DOT #387474 · 4 trucks · 0 drivers · Safety Rating: Satisfactory
FRESENIUS USA MANUFACTURING INC is a small carrier motor carrier based in WALTHAM, Massachusetts (USDOT #387474). As of 2026-07-07T02:59:34.794Z, it holds a Satisfactory FMCSA safety rating and a FileFlo Carrier Intelligence Score of 82/100 (Low Risk), based on 0 recent inspection(s) and 0 recorded violation(s) in public FMCSA data.
Free FMCSA Audit · 3 minutes · No signup
Run a CFR-cited gap audit on FRESENIUS USA MANUFACTURING INC
Pulls the same Socrata data shown above. Grades against the rule pack FileFlo runs internally. Every gap names its 49 CFR section.
22-page PDF · 49 CFR audit prep checklist · 6 templates · Unsubscribe anytime
| Category | Score | Max |
|---|---|---|
| Safety Rating | 30 | 30 |
| Inspection Pass Rate | 15 | 20 |
| Out-of-Service Rate (vs FMCSA national avg) | 8 | 15 |
| CSA BASIC percentiles | Not measured | — |
CIS subtotal normalizes 3 publicly-available FMCSA components (Safety Rating + Inspection Pass Rate + OOS Rate) to a 0–100 surface. CSA SMS BASIC percentiles are not published in FMCSA's public Socrata datasets and the SMS portal at ai.fmcsa.dot.gov is not crawlable at scale, so we surface a transparent "Not measured" rather than fabricate a score component. Carriers with a Compliance Review on record may have published BASIC data on the SAFER snapshot for that DOT.
FRESENIUS USA MANUFACTURING INC is a small carrier operating out of WALTHAM, Massachusetts with USDOT number 387474. The company operates 4 power units and holds a current FMCSA safety rating of Satisfactory. Based on our analysis of federal safety data, FRESENIUS USA MANUFACTURING INC has a FileFlo Carrier Intelligence Score (CIS) of 82/100, classified as Low Risk. This score reflects limited public data — a full roadside-inspection history was not available at page generation, so the inspection and out-of-service components use conservative neutral values.
Limited inspection data is currently available for FRESENIUS USA MANUFACTURING INC. Carriers with fewer recorded inspections may face increased scrutiny during roadside encounters, as FMCSA inspectors may flag them for more thorough reviews.
A CIS score of 82 places FRESENIUS USA MANUFACTURING INC in the Low Risk category. This carrier demonstrates strong safety practices across inspections, maintenance, and driver compliance. Maintaining this score requires ongoing document tracking, timely medical card renewals, and consistent pre-trip inspections.
Motor carriers operating in Massachusetts must comply with both federal FMCSA regulations and state-specific transportation requirements. The WALTHAM, MA corridor is monitored by FMCSA field offices and state highway patrol units conducting roadside inspections. Carriers based in WALTHAM should ensure driver qualification files, vehicle inspection reports, and hours-of-service records are current and audit-ready at all times.
FRESENIUS USA MANUFACTURING INC falls under the Eastern Service Center for FMCSA field-office oversight (region code 01). Service-center territory drives which FMCSA Investigator team would conduct a new-entrant audit or compliance review if one is triggered for this carrier.
FileFlo helps Massachusetts trucking companies automate compliance document tracking across 600+ document types, including CDL medical cards, annual vehicle inspections, drug & alcohol testing records, and driver training certifications.
FRESENIUS USA MANUFACTURING INC is classified by FMCSA as an intrastate non-hazmat carrier.
The carrier is classified as Private Property — meaning it transports its own goods incidental to its primary business, exempt from MC-number authority but still subject to safety regulations under 49 CFR Part 390.
Business organization type: Corporation.
FRESENIUS USA MANUFACTURING INC is flagged in FMCSA Census as a hazardous materials carrier (HM indicator: Y). Hazmat carriers are subject to additional regulations under 49 CFR Subchapter C, including HM-126 reporting, HM-232 security planning, and the Hazmat Cargo Tank Annual Inspection requirement (49 CFR 180.407). Penalties for hazmat violations can reach $89,678 per knowing violation (2026 inflation-adjusted) — substantially higher than the $16,550 baseline.
Operational range per MCS-150 filing: intrastate within 100 miles (8 drivers). The 100-mile boundary matters because drivers operating within a 100-air-mile radius qualify for the short-haul exception under 49 CFR 395.1(e)(1), which removes the requirement to maintain RODS for the day.
Self-reported MCS-150 annual mileage: 21,742,470 miles. MCS-150 mileage feeds the FMCSA SafeStat exposure denominator — drastically understated mileage can artificially inflate CSA BASIC percentile scores by reducing the per-mile exposure baseline. Updates are required every 24 months under 49 CFR 390.19.
The carrier reports 8 CDL-holding drivers on file. Each CDL driver must have a current Driver Qualification File (DQF) maintained per 49 CFR 391.51, including a Medical Examiner's Certificate, an annual MVR review, and a record of road-test results.
Intrastate driver count: 8. Intrastate drivers may be subject to state-specific CDL endorsement and hours-of-service variances depending on the state.
The FMCSA Motor Carrier Management Information System (MCMIS) crash dataset records 20 crash events involving FRESENIUS USA MANUFACTURING INC in the available reporting window. Of these, 1 involved a fatality, 8 involved a reported injury, and 19 resulted in a tow-away. 20 events meet the federal-recordable threshold under 49 CFR 390.5 (fatality, injury treated away from the scene, OR tow-away of any vehicle).
Federal-recordable crashes feed the Crash Indicator BASIC in CSA — carriers above the intervention threshold are 7–10x more likely to be selected for a compliance review than peer carriers below the threshold. Insurance carriers also pull federal-recordable crash counts during quoting; a single recordable crash in a 24-month look-back can drive a 10-20% premium increase for owner-operators and small fleets.
Most recent recorded event: HIGHWAY 155 S AT GREENWOOD INDUSTRIAL PKWY, GA on 20260311.
The free FMCSA audit-readiness score walks through every 49 CFR section a new-entrant audit or compliance review actually checks. Your DOT (387474) prefills automatically; the audit pulls the same Socrata data shown on this page and grades against the rule-pack FileFlo's compliance score actually runs. Three minutes, no signup, no credit card. CFR-cited gap report.
Run the free FMCSA audit for FRESENIUS USA MANUFACTURING INC →
Or skip the audit and start the 5-day FileFlo trial directly: Start Free Trial — $89/mo Starter or $299/mo Professional
Insurance brokers, freight brokers, and DOT compliance consultants vet hundreds of carriers a month. FileFlo's free carrier intelligence is built for you — and clients who use FileFlo get lower insurance premiums, fewer audit findings, and stronger CSA scores.
See the Partner Program → · 5-min application · Approved within 1 business day · Lifetime commission on every referral
No recent inspection records found for FRESENIUS USA MANUFACTURING INC (DOT #387474). New carriers or those with limited interstate operations may have fewer recorded inspections.
FRESENIUS USA MANUFACTURING INC (USDOT #387474) holds a "Satisfactory" FMCSA safety rating. FileFlo's Carrier Intelligence Score for the carrier is 82/100 (Low Risk), derived from its safety rating, inspection pass rate, and out-of-service rate versus the FMCSA national average.
Per its most recent FMCSA MCS-150 filing, FRESENIUS USA MANUFACTURING INC operates 4 power unit(s) and 0 driver(s), classifying it as a small carrier. Fleet counts are self-reported to FMCSA and can lag a carrier's current operation.
FRESENIUS USA MANUFACTURING INC is registered with the FMCSA at a physical address in WALTHAM, Massachusetts, under USDOT number 387474.
No recent DOT inspections are currently on record for FRESENIUS USA MANUFACTURING INC (USDOT #387474) in FMCSA's public Socrata datasets. New carriers and those running limited interstate operations often have few recorded inspections; this is not itself a compliance finding.
FRESENIUS USA MANUFACTURING INC scores 82/100 (Low Risk) on FileFlo's Carrier Intelligence Score. The score normalizes three public FMCSA components — safety rating, inspection pass rate, and out-of-service rate versus the national average — into one 0–100 surface. CSA SMS BASIC percentiles are not published in FMCSA's public data and are excluded rather than estimated.
The 49 CFR sections a DOT compliance review actually checks, plain-English:
Compliance terms: CSA score · out-of-service order · hours of service · driver qualification file. See DOT compliance software & document management →
← Browse All Carriers · Massachusetts Carriers · 2026 FMCSA Penalty Guide · Free FMCSA Audit
Compare the best FMCSA audit prep software →
Data sourced from FMCSA public records and the Socrata transportation dataset. Last updated: 2026-07-07T02:59:34.794Z. Information may not reflect the carrier's current status. Dispute this record · Claim this profile