AMERICAN POWER SYSTEMS LLC, DOT #3057676 FMCSA Safety & Compliance Report
Your latest roadside inspection, Washington on September 11, was written up for company name or USDOT number not shown on the truck. None of it was out of service.
Your MCS-150 lists 15 trucks and 54 drivers.
Every violation on this list stays on your FMCSA record for 24 months and counts toward the scores FMCSA uses to choose carriers for an investigation. The investigator asks for the files behind each one.
AMERICAN POWER SYSTEMS LLC is a small fleet motor carrier based in KENT, Washington (USDOT #3057676). As of November 2, 2026, it holds a Not Rated FMCSA safety rating and a FileFlo Carrier Intelligence Score of 88/100 (Low Risk), based on 7 recent inspection(s) and 7 recorded violation(s) in public FMCSA data.
What AMERICAN POWER SYSTEMS LLC's record points to
- Have FileFlo run your compliance department
Driver files, renewals, Clearinghouse queries, MVRs, drug and alcohol testing and the audit packet, run for you.
Free FMCSA Audit · 60 seconds · No signup
Run a CFR-cited gap audit on AMERICAN POWER SYSTEMS LLC
Pulls the same Socrata data shown above. Grades against the rule pack FileFlo runs internally. Every gap names its 49 CFR section.
Take the book. Free.
238 pages on the paperwork side of trucking. Every checklist in it, yours.
The complete digital edition · Every checklist and template · Unsubscribe anytime
Free FMCSA record alerts
Is this your company? Get free alerts when this record changes.
FileFlo emails you the morning the public FMCSA record for AMERICAN POWER SYSTEMS LLC shows a new roadside inspection, an insurance cancellation or suspension notice, an authority change, the MCS-150 update coming due, or a safety rating change. Free, and FileFlo is not the DOT.
Turn on free alertsCarrier Intelligence Score
88/100 Low Risk
| Category | Score | Max |
|---|---|---|
| Safety Rating | 22 | 30 |
| Inspection Pass Rate | 20 | 20 |
| Out-of-Service Rate (vs FMCSA national avg) | 15 | 15 |
| CSA BASIC percentiles | Not measured | n/a |
Three public FMCSA components, scored by FileFlo. CSA BASIC percentiles are not in FMCSA's public data, so they are shown as not measured.
AMERICAN POWER SYSTEMS LLC's public FMCSA record, line by line
Roadside inspections in the last 24 months
- Sept. 11, 2026, Washington. 2 violations, none out of service. Written up for company name or USDOT number not shown on the truck (49 CFR 390.21).
- July 30, 2026, Idaho. No violations.
- May 18, 2026, California. 2 violations, none out of service. Written up for company name or USDOT number not shown on the truck (49 CFR 390.21).
- Feb. 24, 2025, California. 2 violations, none out of service. Written up for a state or local traffic violation (49 CFR 392.2) and an equipment problem (49 CFR 393.100).
- Dec. 4, 2024, California. 1 violation, none out of service. Written up for lease or Rental Agreement not on board leased or rented CMV (49 CFR 376.11).
AMERICAN POWER SYSTEMS LLC: KENT, Washington Trucking Company
AMERICAN POWER SYSTEMS LLC is a small fleet operating out of KENT, Washington with USDOT number 3057676. The company operates 15 power units and has no published FMCSA safety rating (most active carriers are unrated unless they have undergone a compliance review). Based on our analysis of federal safety data, AMERICAN POWER SYSTEMS LLC has a FileFlo Carrier Intelligence Score (CIS) of 88/100, classified as Low Risk.
FMCSA Safety Record & Inspection History
AMERICAN POWER SYSTEMS LLC has undergone 7 recorded DOT inspections.
Recorded Violations and Out-of-Service Status
The public FMCSA record for AMERICAN POWER SYSTEMS LLC carries 7 recorded violations, and the most recent inspection on file is dated September 11, 2026. Across 7 recorded inspections, the record carries 0 driver out-of-service violations and 0 vehicle out-of-service violations.
A recorded violation is what an inspector wrote down at the roadside. It is not a penalty, and it is not an amount owed: FMCSA assesses civil penalties only after a compliance review classifies specific cited violations. The step that changes this record is the document behind each line, so the next move is to see which records an investigator would ask for and which of them exist today.
What a 88/100 Carrier Intelligence Score Means
The Carrier Intelligence Score is FileFlo's own summary of three public FMCSA components for AMERICAN POWER SYSTEMS LLC: the safety rating, the inspection pass rate and the out-of-service rate against the national average. It is not an FMCSA score, and FMCSA does not use it to choose carriers for an investigation. 88 out of 100 falls in FileFlo's Low Risk band.
Authority Type, Hazmat Status, and Operating Profile
AMERICAN POWER SYSTEMS LLC is classified by FMCSA as an interstate carrier.
The carrier is classified as Private Property, meaning it transports its own goods incidental to its primary business, exempt from MC-number authority but still subject to safety regulations under 49 CFR Part 390.
AMERICAN POWER SYSTEMS LLC is flagged in FMCSA Census as a hazardous materials carrier (HM indicator: Y). Hazmat carriers are subject to additional regulations under 49 CFR Subchapter C, including HM-126 reporting, HM-232 security planning, and the Hazmat Cargo Tank Annual Inspection requirement (49 CFR 180.407). Hazmat violations carry their own, higher penalty schedule, separate from the general FMCSA schedule.
Operational range per MCS-150 filing: interstate beyond 100 miles (long-haul, 21 drivers); intrastate beyond 100 miles (33 drivers). The 100-mile boundary matters because drivers operating within a 100-air-mile radius qualify for the short-haul exception under 49 CFR 395.1(e)(1), which removes the requirement to maintain RODS for the day.
Self-reported MCS-150 annual mileage: 111,814 miles. MCS-150 mileage feeds the FMCSA SafeStat exposure denominator: drastically understated mileage can artificially inflate CSA BASIC percentile scores by reducing the per-mile exposure baseline. Updates are required every 24 months under 49 CFR 390.19.
Fleet Composition and Driver Profile
Owned equipment per the FMCSA Census filing: 10 straight trucks, 2 trailers. Owned-vs-leased equipment matters for compliance documentation, owned trailers require the carrier to retain annual inspection certificates under 49 CFR 396.17, while leased trailers shift that documentation responsibility to the lease agreement.
Intrastate driver count: 33. Intrastate drivers may be subject to state-specific CDL endorsement and hours-of-service variances depending on the state.
Primary cargo type per MCS-150: Tools And Electronic. Cargo type drives which BASIC categories the carrier is monitored under (Hazmat Compliance applies only to HM-flagged carriers; Cargo-Related Crash applies broadly).
AMERICAN POWER SYSTEMS LLC's Inspection Fingerprint: Geographic Pattern and Trend
Inspections cluster geographically across California (4), Washington (2), Idaho (1). The concentration in California is consistent with the carrier's primary lanes and tends to correlate with which state DOT inspector teams AMERICAN POWER SYSTEMS LLC's drivers encounter most often at roadside checkpoints.
How AMERICAN POWER SYSTEMS LLC Compares to the National Average
Across the 7 recorded inspections, AMERICAN POWER SYSTEMS LLC's 0.0% vehicle out-of-service rate sits materially below the FMCSA 2024 national average of 20.72%. The 0.0% driver out-of-service rate sits materially below the 2024 national average of 5.51%.
Have AMERICAN POWER SYSTEMS LLC's compliance file built for you
Your driver files, kept current by FileFlo's software.
Every driver's file built and kept current, every expiration and renewal date in front of you before it lapses, and the audit packet ready on demand. For 5 trucks or 50.
The Audit-Ready Setup is $499. Send your paperwork and USDOT 3057676; FileFlo files every record against the 49 CFR section that requires it, assembles a driver qualification file per driver, builds the vehicle files, and delivers a gap list with the automatic-failure items first plus your audit packet indexed to the CFR. 30 days, every dollar back: if you are not happy with the Setup within 30 days of purchase, FileFlo refunds the full Setup price. Your first 30 days of FileFlo are included. After your 30 included days, Core continues at $199 a month (Fleet, $399, for 16 to 50 trucks) on the same card unless you cancel. We email you 7 days and 1 day before the first charge, and one click in either email cancels it.
- A full gap report inside 24 hours, with the regulation behind every line
- Driver qualification files, vehicle files, and the audit packet in FMCSA review format
- The Radar on USDOT 3057676: one email the day the public record changes
- The guarantee above, printed word for word on the price card
Start the Audit-Ready Setup for AMERICAN POWER SYSTEMS LLC →
Or have FileFlo run it for you: the FileFlo Compliance Department, $1,500 a month, Setup included.
FileFlo
FileFloQuestions: sales@getfileflo.com
See the work: a sample audit packet · how FileFlo handles your data
Want the gap list first? Run the free FMCSA audit for AMERICAN POWER SYSTEMS LLC: sixty seconds, no signup, every gap cited to the 49 CFR section. Or get your free readiness score. See pricing. Read the founder's FMCSA Audit Survival Guide.
Broker or insurance agent? Partner program
Recent DOT Inspections: AMERICAN POWER SYSTEMS LLC
Open any inspection for the records an auditor would ask for behind it: free, from USDOT 3057676, no signup.
| Date | State | Driver OOS | Vehicle OOS | Next step |
|---|---|---|---|---|
| 2026-09-11 | WA | 0 | 0 | Audit check |
| 2026-07-30 | ID | 0 | 0 | Audit check |
| 2026-05-18 | CA | 0 | 0 | Audit check |
| 2025-02-24 | CA | 0 | 0 | Audit check |
| 2024-12-04 | CA | 0 | 0 | Audit check |
| 2024-10-31 | CA | 0 | 0 | Audit check |
| 2024-01-24 | WA | 0 | 0 | Audit check |
Free · No signup
Run a free FMCSA audit on your fleet
Walks every 49 CFR section a new-entrant audit or compliance review actually checks. Every gap names the CFR section that cites it. No signup, no credit card.
Frequently asked questions about AMERICAN POWER SYSTEMS LLC
What is AMERICAN POWER SYSTEMS LLC's FMCSA safety rating?
AMERICAN POWER SYSTEMS LLC (USDOT #3057676) does not currently carry a published FMCSA safety rating. A "Not Rated" status is common for carriers that have never had a compliance review: it is not a negative finding. FileFlo scores the carrier at 88/100 (Low Risk) from the public inspection and out-of-service data that is available.
How large is AMERICAN POWER SYSTEMS LLC's fleet?
Per its most recent FMCSA MCS-150 filing, AMERICAN POWER SYSTEMS LLC operates 15 power unit(s) and 54 driver(s), classifying it as a small fleet. Fleet counts are self-reported to FMCSA and can lag a carrier's current operation.
Where is AMERICAN POWER SYSTEMS LLC based?
AMERICAN POWER SYSTEMS LLC is registered with the FMCSA at a physical address in KENT, Washington, under USDOT number 3057676.
What is AMERICAN POWER SYSTEMS LLC's DOT inspection and violation history?
FileFlo shows 7 recent DOT inspection(s) and 7 recorded violation(s) for AMERICAN POWER SYSTEMS LLC (USDOT #3057676), sourced from FMCSA public records and the Socrata transportation datasets. The inspection table on this page lists dates, states, and out-of-service counts.
What is AMERICAN POWER SYSTEMS LLC's FileFlo Carrier Intelligence Score?
AMERICAN POWER SYSTEMS LLC scores 88/100 (Low Risk) on FileFlo's Carrier Intelligence Score. The score normalizes three public FMCSA components (safety rating, inspection pass rate, and out-of-service rate versus the national average) into one 0-100 surface. CSA SMS BASIC percentiles are not published in FMCSA's public data and are excluded rather than estimated.
Federal rules a carrier like AMERICAN POWER SYSTEMS LLC is audited against
The 49 CFR sections a DOT compliance review actually checks, plain-English:
- 49 CFR 395.8, Hours of service & ELD records
- 49 CFR 391.51, Driver qualification files (DQF)
- 49 CFR 396.3, Vehicle inspection, repair & maintenance
- 49 CFR 382.301, Pre-employment drug & alcohol testing
Compliance terms: CSA score · out-of-service order · hours of service · driver qualification file. See DOT compliance software & document management →
More Washington carriers on file
- DAS HOLDINGS LLC, PASCO (USDOT 3057937)
- REDSTAR LOGISTICS LLC, AUBURN (USDOT 3059052)
- RATAUL TRANSPORT LLC, MAPLE VALLEY (USDOT 3059399)
- ROYAL HONEY FARM LLC, OTHELLO (USDOT 3059782)
- EAGLE LOGISTICS LLC, VANCOUVER (USDOT 3062566)
- ELITE ENVIRONMENTAL SERVICES LLC, YAKIMA (USDOT 3062838)
← Browse All Carriers · Washington Carriers · 2026 FMCSA Penalty Guide · Free FMCSA Audit
Compare the best FMCSA audit prep software →
Data sourced from FMCSA public records and the Socrata transportation dataset. Last updated: November 2, 2026. Information may not reflect the carrier's current status. Dispute this record · Claim this profile